3 recalls found. |
DEFECT #1 - SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Posted on: 2002-04-23
Description
On certain school buses, the brake hoses from the chassis to front brake chambers could develop leaks due to the hose routing that could overstress the hose during sharp turns.
Consequence
The vehicle could have reduced braking capacity, increasing the risk of a crash.
Corrective Action
Dealers will inspect for improper routing. If improper routing is found, dealers will replace and correct the hose routing. Owner notification began april 29, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact freightliner at 1-800-547-0712.
Notes
Customers can also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - FUEL SYSTEM, DIESEL
Posted on: 2005-05-06
Description
Certain 1998-2003 my freightliner fs-65 school bus chassis and mb-45, mb-55, and xb shuttle bus chassis, and thomas built bus: mvp-er and mvp-ef school bus and non-school bus models equipped with cummins isb diesel engines and equipped with federal-mogal 12 and 24 volt fuel lift pumps. The fuel pump could fail to transfer fuel appropriately creating an engine stall condition.
Consequence
Should the engine stall while the vehicle is in use, a possible vehicle crash could occur.
Corrective Action
Cummins will notify the customers of freightliner and thomas built and replace the fuel lift pump free of charge. Owners may contact cummins at 1-800-diesels.
Notes
Customers may also contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to http://www.safercar.gov.
DEFECT #3 - SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Posted on: 2004-07-12
Description
On certain school buses chassis equipped with caterpillar engines and hydraulic brakes. A braided ground strap for the starter may rub on a steel chassis brake line potentially causing a fluid leak.
Consequence
A brake fluid leak can reduce braking effectiveness and increase the stopping distance, which could result in a crash.
Corrective Action
Dealers will inspect the brake line and replace it, if necessary. The braided ground strap will be replaced with an insulated cable. The recall began on august 10, 2004. Owners may contact freightliner at 1-800-547-0712.
Notes
Freightliner recall no. Fl-421.also, customers can contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).