7 recalls found. |
DEFECT #1 - VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
Posted on: 1998-12-14
Description
Vehicle description: school buses built on a navistar chassis. The cross view mirrors do not comply with the requirements of fmvss no. 111, rearview mirrors. The entire top surface of cylinder h is not visible as required.
Consequence
A driver may not be able to see certain portions of the bus increasing the risk of a crash or personal injury to persons near the bus.
Corrective Action
Owners will be provided with a repair kit and detailed instructions. If an owner so desires, thomas built dealers can perform the repair for them.
Notes
Owner notification began april 27,1999. Owners who do not receive the free repair kit and installation instructions within a reasonable time should contact thomas built at 1-910-889-4871.also contact the national highway traffic safety administration's auto safety hotline at 1-888-dash-2-dot (1-888-327-4236).
DEFECT #2 - SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Posted on: 1995-03-06
Description
The bracket used to support the hydraulic brake line can crack and possibly sever the brake line.
Consequence
If the brake line is severed, braking capability will be immediately reduced, increasing the potential for a vehicle accident.
Corrective Action
Dealers will reroute the hydraulic brake line.
Notes
System: brakes; hydraulic; lines; fittings.vehicle description: school and transit buses.note:if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge within a reasonabletime, contact thomas built at 1-910-889-4871. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #3 - SEAT BELTS:FRONT:RETRACTOR
Posted on: 1995-01-24
Description
The metal housing of the safety belt retractors on automatic locking retractor/emergency locking retractor safety belts can become deformed preventing extension and/or retraction of the belt.
Consequence
Passengers would be unable to extend or retract their safety belts and would be at a risk of injury in the event of an accident.
Corrective Action
Dealers will install a hardened washer which will decrease the possibility of deformation of the safety belt retractor. Damaged retractors will be replaced.
Notes
System: interior system; active restraints; belt retractors.vehicle description: transit and school buses.note: if the vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge within a reasonable time, please contact thomas built at 1-910-889-4871. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #4 - STRUCTURE:BODY
Posted on: 1996-07-24
Description
An item worn by a child, such as a long drawstring, sash, or backpack/bookbag accessory, can become caught in the area between the service door and the door control rod attaching bracket.
Consequence
If an item worn by a child were to catch on this area, and the driver were to close the door and put the vehicle in motion, this can result in serious injury or death.
Corrective Action
A molded cover will be installed between the manually operated outward opening entrance door and the door control rod attaching bracket which will eliminate the opening that could allow an item of a child's clothing to become snagged.
Notes
System: structure; body; handrails. Vehicle description: school buses equipped with manually operated outward opening service doors. Note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 1-910-889-4871. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #5 - VISIBILITY:DEFROSTER/DEFOGGER SYSTEM:WINDSHIELD:HEATER CORE
Posted on: 1995-03-06
Description
If paper or trash falls down the red dot heater vents it could ignite.
Consequence
This condition can cause a heater fire and an increased potential for a vehicle accident.
Corrective Action
Dealers will install a wire cage around the heater resistor.
Notes
System: heater; water; defroster; hose; duct; air.vehicle description: school and transit buses equipped with red dot heaters.note: if your vehicle is presented to an authorized dealer on an agreed upon service date and the remedy is not provided free of charge within a reasonable time, contact thomas built at 1-910-889-4871. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.
DEFECT #6 - VISIBILITY:GLASS, SIDE/REAR
Posted on: 1993-02-05
Description
The current production stationary window assemblies allow the glass to disengage from the rubber and/or frame.
Consequence
The windows do not comply with fmvss 217, bus windowretention and release.
Corrective Action
Install two retaining clips at each non-complying window.
Notes
System: visual systems; fmvss 217.vehicle description: buses and school buses.
DEFECT #7 - STRUCTURE:BODY
Posted on: 1996-06-21
Description
An item worn by a child, such as a long drawstring, sash, or backpack/bookbag accessory can become caught in a small opening at the floor level of the forward door post.
Consequence
A passenger's clothing could become caught in the small opening and if the bus driver closes the door and puts the vehicle in motion, the individual is subject to being dragged by the bus. This can result in serious injury or death.
Corrective Action
A filler plate will be attached on thomas conventionals or a piece of rubber trim on thomas vistas to the forward door post at the floor level to cover the opening and eliminate the possibility of snagging.
Notes
System: structure; body; handrails. Vehicle description: school buses equipped with certain front heater options and outward opening service doors. Note: owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact thomas built at 1-910-889-4871. Also contact the national highway traffic safety administration's auto safety hotline at 1-800-424-9393.