3 recalls found. |
DEFECT #1 - SERVICE BRAKES, HYDRAULIC:POWER ASSIST
Posted on: 1979-10-12
Description
Consequence
Corrective Action
Notes
Ford campaign no n/a.trucks.possibility that vehicles were assembled withimproperly installed shoulder bolt and attaching nut that secures the brakepedal to the master cylinder/vacuum booster pushrod.if this condition exists,the available bolt threads may not be enough to retain nut properly, and couldback-off permitting pushrod to separate from brake pedal.(correct byinspecting and replacing bolts and attaching nut and torqued tospecifications).light truck - pick-up.
DEFECT #2 - SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS
Posted on: 1979-10-12
Description
Consequence
Corrective Action
Notes
Ford truck campaign no 196 4x4.light duty trucks.possibility trucks mayhave been produced with insufficient clearance between the brake masterscylinder primary or secondary outlet tube and the intermediate steering shaft.assembly methods resulted in deformation of the tube support bracket andmisassembly of the brake tubes to the inboard side of the tube support barcket.a bent support bracket in combination with inboard mounting of brake tubescould cause tube to contact the steering shaft and, eventually could result inwearing a hole in tube wall.should this occur, brake fluid and hydraulicpressure would be lost in either the front or rear portion of the dual brakesystem.the operator would be warned by brake light and an increase in brakepedal travel.(correct by inspecting and replacing tube that have been incontact with steering shaft.also, adjust clearance to be.75 inch or more).
DEFECT #3 - FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
Posted on: 2007-08-24
Description
Certain federal-mogul aftermarket fuel pumps sold under the brand names of carter, accuflow, napa, truflow, parts depo, and parts master, shipped between august 2006 and july 2007 for use on the vehicles listed above. The fuel pump diaphragm in certain production runs may have been improperly installed or inadequately tested which may cause the fuel pump to leak.
Consequence
A leaking fuel pump could create a vehicle fire hazard.
Corrective Action
Federal-mogul will notify owners and replace the defective fuel pumps free of charge. The recall began on october 15, 2007. Owners can contact federal-mogul at 248-354-7700.
Notes
This recall only pertains to aftermarket carter, napa, accuflow, tru flow, parts master, and parts depot brand fuel pumps and has no relation to any original equipment installed on the listed motor vehicles.customers may contact the national highway traffic safety administration's vehicle safety hotline at 1-888-327-4236 (tty: 1-800-424-9153); or go to http://www.safercar.gov.